Product ID:TT-L-20A 37038 BLACK FLAT LACQUER MIL SPEC LACQUER 20A-37038
MSDS Date:05/28/1991
FSC:8010
NIIN:00F040914
MSDS Number: BXMQQ

RANDOLPH PRODUCTS CO

701 12TH ST
CARLSTADT, NJ 07072-0830
US

Emergency Phone: 201-438-3700/800-255-3924

Info Phone: 201-438-3700/800-255-3924

Cage: 77672

RANDOLPH PRODUCTS CO

830 CARLSTADT, NJ 07072-0830 US

Telephone: 201-438-3700

Cage: 77672

TOLUENE (IARC CARC- GROUP 3) *95-2*

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 10-25%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

COLUMBIA CARBON, CARBON BLACK, LAMPBLACK, BLACK PEARLS

CAS: 1333-86-4

RTECS: FF5800000

Fraction By Weight: 10-15%

OSHA PEL 3.5 MG/CUM

ACGIH TLV: 3.5 MG/CUM

DI-SEC-OCTYL PHTHALATE, BIS (2-ETHYLHEXYL) PHTHALATE (DOP),

CAS: 117-81-7

RTECS: TI0350000

Fraction By Weight: 5%

OSHA PEL 5 MG/CUM

ACGIH TLV: 10 MG/CUM

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

SHORT COCONUT ALKYD

Fraction By Weight: 5%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

WET NITROCELLULOSE, NITROCELLULOSE, NITRATE CELLULOSE

CAS: 9004-70-0

RTECS: QW0975200

Fraction By Weight: 20%

ACETONE; DIMETHYL KETONE; 2-PROPANONE

CAS: 67-64-1

RTECS: AL3150000

Fraction By Weight: 5%

OSHA PEL 2400 MG/CUM

ACGIH TLV: 750 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

BUTYL ACETATE (N-BUTYL ACETATE) *95-2*

CAS: 123-86-4

RTECS: AF7350000

Fraction By Weight: 10%

OSHA PEL 710 MG/CUM

ACGIH TLV: 713 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ETHYL ACETATE

CAS: 141-78-6

RTECS: AH5425000

Fraction By Weight: 15%

OSHA PEL 400 PPM

ACGIH TLV: 1400 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ETHANOL (ETHYL ALCOHOL), TECSOL, ALCOHOL

CAS: 64-17-5

RTECS: KQ6300000

Fraction By Weight: 5-10%

OSHA PEL 1000 PPM

ACGIH TLV: 1000 PPM

ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: 10%

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM

MEDIUM ALIPHATIC NAPHTHA (AROMATIC 100), PARAFFIN-NAPTHANES

CAS: 64742-88-7

Fraction By Weight: 15%

OSHA PEL 400 PPM

2-BUTANONE (METHYL ETHYL KETONE) (MEK)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 10%

OSHA PEL 200 PPM

ACGIH TLV: 590 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

LACQUER THINNER

Fraction By Weight: 5%

OSHA PEL 100 PPM

ACGIH TLV: 150 PPM

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION. POTENTIAL CANCER
CAUSING AGENT. REACTS W/PROTEIN & MOISTURE & CAN CAUSE RASH,
SCALING/BLISTERING. HIGH CONCENTRATIONS ARE ANESTHETIC & MAY HAVE
OTHER CNS EFFECTS, INCLUDING DEATH.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION, DRYING, CRACKING, RASH, SCALING,
BLISTERING, HEADACHES, DIZZINESS.
Medical Cond Aggravated by Exposure:PRE-EXISTING SENSITIVITY TO
SOLVENTS CAN CAUSE A HEIGHTENED REACTION TO EXPOSURE TO PRODUCT.

First Aid:INHALATION: REMOVE TO FRESH AIR, RESTORE BREATHING. SKIN:
FLUSH W/WATER. EYES: FLUSH IMMEDIATELY W/LARGE AMOUNTS OF WATER.
INGESTION: DON'T INDUCE VOMITING. KEEP WARM, QUIET. SMALL AMOUNTS
OF LIQUID A SPIRATED INTO THE RESPIRATORY SYSTEM DURING
INGESTION/FROM VOMITING, MAY CAUSE CHEMICAL PNEUMONIA/PULMONARY
EDEMA. OBTAIN MEDICAL ATTENTION IN ALL CASES.

Flash Point Method:SCC
Flash Point:-4F
Lower Limits:0.3
Upper Limits:19
Extinguishing Media:DRY CHEMICAL, CO2, FOAM
Fire Fighting Procedures:WATER STREAM WILL SPREAD FIRE. DON'T USE WATER
HOSE STREAM. FULL BUNKER GEAR IN AREA (HELMET W/FACE SHIELD, BUNKER
COAT, GLOVES, RUBBER BOOTS).
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. WATER MAY BE USED TO COOL CONTAINERS.
REMOVE ALL NON-ESSENTIAL PERSONNEL FROM FIRE AREA. (SUPP)

Spill Release Procedures:AVOID SPARKS/FLAMES. ELIMINATE SOURCE IF CAN
W/OUT RISK BY CLOSING VALVE, PLUGGING HOLE. APPLY ABSORBENT INERT
MATERIAL. CLEAN W/BRISTLE BROOMS, NON-SPARKING TOOLS, CLEAN DRY
RAGS. PROTECTIVE CLOTHING SHOULD BE WORN.

Handling and Storage Precautions:DRUMS SHOULD BE GROUNDED WHEN BEING
EMPTIED.
Other Precautions:AVOID SKIN/EYE CONTACT. AVOID BREATHING SOLVENT
VAPOR.

Respiratory Protection:NIOSH/OSHA APPROVED RESPIRATOR IS RECOMMENDED.
APPROVED CHEMICAL/MECHANICAL FILTERS RECOMMENDED WHEN VENTILATION
IS RESTRICTED.
Ventilation:SUFFICIENT VENTILATION
Protective Gloves:REQUIRED
Eye Protection:CHEMICAL GOGGLES W/SIDE SHIELDS
Other Protective Equipment:FACE SHIELD REQUIRED.
Work Hygienic Practices:USE NORMAL HYGIENE PRACTICES DURING & AFTER
HANDLING THIS MATERIAL.
Supplemental Safety and Health
UNUSUAL FIRE CONT'D: VAPOR IS >THAN AIR & CAN TRAVEL TO IGNITION
SOURCES & FLASHBACK. WASTE CONT'D: TRANSFER LIQUID TO CONTAINERS
FOR RECOVERY/DISPOSAL.

Boiling Pt:B.P. Text:83-285F
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:THIN BLACK LIQUID W/TYPICAL OF PAINT ODOR.
Percent Volatiles by Volume:77.6

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ACIDS & ALKALIES.
Stability Condition to Avoid:EXTREME HEAT, SPARKS, OPEN FLAMES.
Hazardous Decomposition Products:CO, CO2.

Waste Disposal Methods:SOAK LIQUIDS W/SAWDUST/RAGS & REMOVE. FLUSH
W/WATER IF POSSIBLE. DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. DON'T INCINERATE, CUT/WELD EMPTY CONTAINERS. WHEN
DISCARDED THIS MATERIAL IS A HAZAR DOUS WASTE. (SEE SUPP)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.